韩国VOLTEX蓄电池铅酸免维护阀控式应急电源-原装进口

韩国VOLTEX蓄电池铅酸免维护阀控式应急电源-原装进口

韩国Voltex蓄电池特点：

8年设计寿命

吸附式玻璃纤维棉技术使气体符合效率高达99%，使电解液具有免维护功能

1年质保期（参照 Dynasty质保卡，41-9026）

获专利的低钙合金设计，在工业领域中具有代理低的含钙量，代理大限度的降低板栅的增长、气体的生成，延长了电池的寿命

每个单格中都装有获得专利及UL认证的阻燃排气阀，使电池更安全且具有更长的寿命

Features of South Korea voltex battery:

8 years design life

Adsorption glass fiber cotton technology makes the gascoincidence efficiency as high as 99%, and the electrolyte hasmaintenance free function

1 year warranty period (refer to Dynasty warranty card,41-9026)

The patented low calcium alloy design, in the industrial field,has the agent of low calcium content, agent greatly reduce the gridgrowth, gas generation, prolong the life of the battery

Each cell is equipped with patented and UL certifiedflame-retardant exhaust valve, which makes the battery safer andlonger life

具有一致的再复合设计，热失控保护，防止气体生成及阻燃的特点，符合Bellcore4228

阻燃的聚丙烯（PP）槽盖，符合UL1778

With consistent recombination design, thermal runawayprotection, gas generation prevention and flame retardantcharacteristics, it conforms to Bellcore 4228

独有的固定孔的极板涂膏技术，使活性物质在板栅两面均匀填涂，使每个单格的板栅具有一致性，增加了电池的容量，保护了极板的一致性电池槽盖的热封粘结可以杜绝渗漏

Flame retardant polypropylene (PP) tank cover to ul1778

The unique paste coating technology of fixing holes makes theactive substance evenly fill on both sides of the grid, making thegrid of each single grid consistent, increasing the capacity of thebattery, and protecting the consistency of the plate. The heatsealing bonding of the battery slot cover can prevent leakage

Voltexbattery韩国Voltex蓄电池（电瓶）中国总代理产品特点：
因为是紧装配合，全密封设计，不需要为电池单独准备一个电池房。按VDE0510第二部分，Drypower在安装电池时的通风要求可作适当减低。电池可以置于电子机箱内以节约运行空间，也不效地节约安装费用。在用作储备能源和与应急设备相连处于浮充状态时预期寿命为8年（假设电解液温度为20度）。只要VDE0510第2部分的通风标准允许，电池的密封设计使其用于任何场所和电池箱内。

Voltexbattery Korea voltex battery China general agent productfeatures:

Because it is a tight fit and fully sealed design, there is noneed to prepare a separate battery room for the battery. At thesame time, according to the second part of vde0510, the ventilationrequirements of drypower when installing batteries can beappropriately reduced. The battery can be placed in the electronicchassis to save running space and installation cost. The lifeexpectancy is 8 years when it is used as reserve energy andconnected with emergency equipment in floating state (assumingelectrolyte temperature is 20 ℃). As long as the ventilationstandard of vde0510 Part 2 allows, the sealed design of the batterymakes it used in any place and battery box.

用途:
1.电解液吸附在玻璃纤维中
=减少维护（不需要加水）
=水平放置（供选择）
2.回火保护装置和集成于电池盖上的中央排气系统
=免除爆炸危险
3.带有手柄的平滑电池盖
=易于清洗的表面
=易于提携
4.集成端子、系统连接件
=抗腐蚀性
=在安装时也能防止短路现象的发生
5.使用寿命 大于6年（根据EUROBAT)

产品优点：电解液吸附在纤维中 减少维护（不需要加水） 水平放置（供选择）回火保护装置和集成于电池盖上的中央排气系统免除爆炸危险代理大能量密度 很小的电池尺寸要求带有手柄的平滑电池盖 易于清洗的表面 易于提携集成端子/系统连接件 抗腐蚀性在安装时也能防止短路现象的发生

－外壳及密封系统：蓄电池外壳应采用强化聚丙烯制成，并满足以下要求：

·抗失水性能高，防止电池电解液流失；抗氧气渗透性好，防止阳极氧化；

·机械强度高，能够长时间承受蓄电池内、外压差的压力和运输过程中的外力撞击。

Voltexbattery韩国Voltex蓄电池（电瓶）中国总代理极柱及密封系统

Application:

1. The electrolyte is adsorbed in the glass fiber

=Reduced maintenance (no need to add water)

=Horizontal placement (optional)

2. Flashback protection device and central exhaust systemintegrated on battery cover

=Avoid explosion hazard

3. Smooth battery cover with handle

=Easy to clean surface

=Easy to carry

4. Integrated terminal and system connector

=Corrosion resistance

=Even in the installation, it can prevent the occurrence ofshort circuit

5. Service life greater than 6 years (according to eurobat)

Product advantages: electrolyte adsorbed in fiber reducesmaintenance (no need to add water) horizontal placement (optional)tempering protection device and central exhaust system integratedon battery cover avoid explosion hazard agent large energy densitysmall battery size requires smooth battery cover with handle easyto clean surface easy to carry integrated terminal / systemconnector corrosion resistance Even in the installation, it canprevent the occurrence of short circuit

采用有螺纹的铜质极柱，可承受大电流（包括电池短路电流）的通过，当以30I10放电3min时，极柱不应熔断，其外观不应出现异常。

极柱采用氩弧焊接方式，充分保证极柱根部周围密封良好，避免由于密封不严造成日后运行中出现极柱渗漏现象。

蓄电池的正、负端子便于连接，并有明显标志。蓄电池端子应采用螺栓、螺母连接，蓄电池之间的连接电压降△U≤10mV防爆型安全阀

电池开阀压力在11 kPa～18 kPa范围内，闭阀压力应在5.6kPa～8.7 kPa范围内，可靠性不小于5万次。排气阀动作更加灵敏。

正、负极板

 enclosure and sealing system: the enclosure of batteryshall be made of reinforced polypropylene and meet the followingrequirements:

·It has high water loss resistance to prevent electrolyte loss,good oxygen permeability to prevent anodic oxidation, and lowcost;

·It has high mechanical strength and can bear the pressure ofinternal and external pressure difference of battery and the impactof external force during transportation for a long time.

South Korea voltex battery China general agent pole and sealingsystem

The threaded copper pole can withstand the passage of largecurrent (including battery short-circuit current). When dischargingwith 30i10 for 3min, the pole should not be fused and itsappearance should not be abnormal.

The argon arc welding method is adopted for the pole to fullyensure the good sealing around the root of the pole and avoid theleakage of the pole in future operation due to the lax sealing.

正负极板采用铅钙锡多元合金制成，并具有以下特点：

·可承受高速率充电；

·深度放电后复原性强，80％DOD充、放电循环次数不小于700周期；

·氢气析出电压不应小于2.40V，失水少，具有较好维护性；

·有较好的硬度和强度；

·有有效措施防止熔融态钙合金中钙的损失；

·极板固化良好，不出现脱粉、掉块、表面产生裂纹现象；

·有效控制铁、锰、砷、氯、铜等杂质的含量，避免电池中氧析出量增多，造成自放电增大。

Positive and negative plates

The positive and negative plates are made of Pb Ca Sn alloy andhave the following characteristics:

·Can withstand high rate charging;

·The number of charge and discharge cycles of 80% DOD is notless than 700 cycles;

·The hydrogen precipitation voltage should not be less than2.40v, with less water loss and better maintainability;

·It has good hardness and strength;

·There are effectie measures to prevent the loss of calcium inmolten calcium alloy;

·The plate is well solidified, and there is no powder falling,block falling and surface crack;

·Effectively control the content of iron, manganese, arsenic,chlorine, copper and other impurities to avoid the increase ofoxygen precipitation in the battery, resulting in the increase ofself discharge.